This article has been reviewed according to Science X's editorial process and policies. Editors have highlighted the following attributes while ensuring the content's credibility:

fact-checked

trusted source

proofread

Storing hydrogen in coal may help power clean energy economy

Storing hydrogen in coal may help power clean energy economy
A Penn State researcher holds a large piece of coal. Credit: Penn State

The quest to develop hydrogen as a clean energy source that could curb our dependence on fossil fuels may lead to an unexpected place—coal. A team of Penn State scientists found that coal may represent a potential way to store hydrogen gas, much like batteries store energy for future use, addressing a major hurdle in developing a clean energy supply chain.

"We found that can be this geological hydrogen battery," said Shimin Liu, associate professor of energy and mineral engineering at Penn State. "You could inject and store the hydrogen energy and have it there when you need to use it."

Hydrogen is a clean burning fuel and shows promise for use in the most energy intensive sectors of our economy—transportation, electricity generation and manufacturing. But much work remains to build a and make it an affordable and reliable energy source, the scientists said.

This includes developing a way to store hydrogen, which is currently expensive and inefficient. Geologic formations are an intriguing option, the scientists said, because they can store large amounts of hydrogen to meet the peaks and valleys as energy demand changes daily or seasonally.

"Coal is well-studied, and we have been commercially producing gas from coal for almost a half century," Liu said. "We understand it. We have the infrastructure. I think coal would be the logical place to do geological hydrogen storage."

To put this to the test, the scientists analyzed eight types of coals from coalfields across the United States to better understand their sorption and diffusion potential, or how much hydrogen they can hold.

All eight coals showed considerable sorption properties, with low-volatile bituminous coal from eastern Virgina and anthracite coal from eastern Pennsylvania performing the best in tests, the scientists reported in the journal Applied Energy.

"I think it's highly possible that coal could be the very top selection for geological storage from a scientific perspective," said Liu. "We find that coal outperforms other formations because it can hold more, it has existing infrastructure and is widely available across the country and near populated areas."

Depleted coalbed methane reservoirs may be the best candidates. These seams contain unconventional natural gas like methane and have become an important source of fossil fuel energy over the last several decades. The methane sticks to the surface of the coal, in a process called adsorption.

Similarly, injecting hydrogen into coal would cause that gas to absorb or stick to the coal. These formations often have a layer of shale or mudstone on top that act as a seal keeping methane, or in this case hydrogen, sealed until it is needed and pumped back out, the scientists said.

"A lot of people define coal as a rock, but it's really a polymer," Liu said. "It has high carbon content with a lot of small pores that can store much more gas. So coal is like a sponge that can hold many more hydrogen molecules compared to other non-carbon materials."

The scientists designed special equipment to conduct the experiments. Coal has a weaker affinity with hydrogen compared to other sorbing gases like methane and carbon dioxide, so traditional pressurized equipment for determining sorption would not have worked.

"We did a very novel and very challenging design," Liu said. "It took years to figure out how to do this properly. We had to properly design an experiment system, trial and error based on our previous experience with coals and shales."

Based on their results, the scientists determined anthracite and semi-anthracite coals are good candidates for hydrogen storage in depleted coal seams, and low-volatile bituminous coal are better candidates for gassy coal seams.

Developing hydrogen storage in coal mining communities could bring new economic opportunities to these regions while also helping create the nation's hydrogen infrastructure.

"In the energy transition, it's really coal communities that have been the most impacted economically," Liu said. "This is certainly an opportunity to repurpose the coal region. They already have the expertise—the energy engineer and skills. If we can build an infrastructure and change their economic opportunities—I think that's something we should consider."

Future work will focus on the dynamic diffusivity and dynamic permeability of coal, features which determine how quickly can be injected and pumped back out, the scientists said.

"I think Penn State is the right place to do all this research—we have the , we have natural gas, we have both the engineering and economic expertise at the University," Liu said. "This is the logical place to do this."

More information: Ang Liu et al, Hydrogen sorption and diffusion in coals: Implications for hydrogen geo-storage, Applied Energy (2023). DOI: 10.1016/j.apenergy.2023.120746

Citation: Storing hydrogen in coal may help power clean energy economy (2023, May 25) retrieved 28 March 2024 from https://techxplore.com/news/2023-05-hydrogen-coal-power-energy-economy.html
This document is subject to copyright. Apart from any fair dealing for the purpose of private study or research, no part may be reproduced without the written permission. The content is provided for information purposes only.

Explore further

What is hydrogen, and can it really become a climate solution?

53 shares

Feedback to editors