This article has been reviewed according to Science X's editorial process and policies. Editors have highlighted the following attributes while ensuring the content's credibility:

fact-checked

proofread

Photocatalytic concrete for clean air in underground tunnels

Photocatalytic concrete for clean air in underground tunnels
An artificial light source has been installed, allowing the photocatalytic function to work even underground where natural light does not reach. Credit: Korea Institute of Civil Engineering and Building Technology

The air quality in underground road tunnels tends to be worse than in other road environments due to the poor air circulation. To address this issue, researchers at the Korea Institute of Civil Engineering and Building Technology (KICT) have developed photocatalytic concrete that can effectively remove fine particulate matter on roads.

The most effective way to improve internal in is to pre-emptively remove fine particulate matter precursors generated by automobile exhaust gases. Therefore, the application of construction materials that make use of photocatalysts with the capability to remove has recently been in the spotlight as a solution to fine particulate matter pollution.

A photocatalyst is a semiconducting material that can break down pollutants through a photocatalytic reaction when exposed to light. Photocatalysts react with light to produce (ROS) with strong oxidizing power, which converts the precursors of fine particulate matter (nitrogen oxide, sulfur oxide, etc.) into harmless substances through a photocatalytic reaction, leading to suppression of fine particulate matter generation.

KICT's Green Construction by Photocatalyst Research Group (GCP Research Group) has developed a photocatalytic concrete that can reduce fine particulate matter generation through the strong oxidizing power of ROS generated when the reacts with light.

Photocatalytic concrete for clean air in underground tunnels
The NOx concentration level decreased by approximately 18% 24 hours after the application of the photocatalytic concrete. This data represents the average value of the entire measurement period (2022.12.14. ~ 2023.01.12., 4 weeks). Credit: Korea Institute of Civil Engineering and Building Technology

Despite the excellent performance of photocatalysts in removing toxic substance from the air, they have yet to be used in construction materials due to high manufacturing cost; As a result, the GCP Research Group has been developing key technologies for cost-efficient mass production of photocatalysts from wastewater sludge since 2018, with the support of the Ministry of Land, Infrastructure and Transport. Through this project, the GCP Research Group succeeded in developing a photocatalytic and application technology that achieved both technical performance and economic competitiveness.

In May 2023, the GCP Research Group completed a trial application of photocatalytic concrete on the inner walls of the Banpo Underground Road Tunnel in Seoul, Korea. This trial aimed to verify the effectiveness of the research findings in actual use. The outcomes showed an approximate 18% reduction in nitrogen oxides (NOx) concentration levels over a period of 24 hours.

An artificial light source was installed on the wall of the underground road tunnel where the photocatalytic concrete was applied, allowing the photocatalytic function to work even underground where natural light does not reach. Additionally, the outcomes demonstrated that the products of photocatalytic degradation, which that converted into salts due to the calcium content in photocatalytic concrete, were effectively washed away by rain. This allows the photocatalytic function to last permanently without the need for maintenance.

Photocatalytic concrete for clean air in underground tunnels
Mechanism of photocatalytic degradation of air pollutants on the surface of photocatalytic concrete. Credit: Korea Institute of Civil Engineering and Building Technology

The GCP research group is also conducting research to establish various photocatalytic performance evaluation certification systems. aiming to facilitate the commercialization and distribution of the technology. Currently, they are conducting a comprehensive trial in collaboration with authorities in Gyeonggi-do Province to demonstrate the effectiveness of construction technologies.

"Construction technology using photocatalysts can have an immediate effect on reducing in the nation's living environment," said Dr. Jong-Won, Kwark, head researcher of the research. "We plan to build a system of cooperation with and public corporations to expand trial demonstrations to other sites to achieve commercialization and distribution with practical effects."

More information: Hyunno Yoon et al, NOx-removal and Sound-absorption Performances of Photocatalytic Porous Concrete Prepared by Various TiO2 Application Methods, KSCE Journal of Civil and Environmental Engineering Research (2023). DOI: 10.12652/Ksce.2022.42.2.0163. journal.auric.kr/jksce/XmlViewer/f412525

Provided by National Research Council of Science & Technology
Citation: Photocatalytic concrete for clean air in underground tunnels (2023, June 5) retrieved 15 July 2024 from https://techxplore.com/news/2023-06-photocatalytic-concrete-air-underground-tunnels.html
This document is subject to copyright. Apart from any fair dealing for the purpose of private study or research, no part may be reproduced without the written permission. The content is provided for information purposes only.

Explore further

Photocatalytic technology improved with TiO2 nanotube arrays and nanobubbles

4 shares

Feedback to editors